To ensure the normal life of vehicles and obtain the good economic benefit, all the instructions of the maintenance requirements mentioned need strictly to be followed.
Pure fuel in accordance with the quality requirement is required to be used during the vehicle’s running. All chosen oil, lubricating oil, hydraulic oil etc. for vehicles shall be consistent with the provided grades of this manual.
We reserve the rights of technical alteration and upgrades for better improvement without prior notice.
|
Assembly |
Petroleum Product |
Brand |
Volume |
|
Fuel tank capacity（L） |
Diesel |
Diesel which apply to the local temperature |
400 or 300 |
|
Engine Cooling system（L） |
Long-lasting antifreeze anti-corrosion coolant |
Heavy duty long-lasting antifreeze anti-corrosion coolant used in four seasons |
40 |
|
Engine Lubrication system（L） |
Engine Oil |
CH-4 Grade |
23 |
|
Transmission（L） |
Gear oil of heavy duty vehicles |
85W/90 GL-5 |
13 |
|
Clutch（L） |
Brake fluid |
SAE 116/DOT3 |
About 1L |
|
Steering（L） |
hydraulic liquid |
HVN32 Low temperature hydraulic liquid |
3.5 |
|
Rear-axle final drive and bush bearing（L） |
Gear oil of heavy duty vehicles |
GL-5EP 80W/90 or GL-5EP 85W/140 |
23 |
|
Tilt-cab assembly |
hydraulic liquid |
HVN32 Low temperature hydraulic liquid |
0.4 |
|
WG I |
WG II |
WG III |
|
Mileage per year less than 2x 10 ⁴ km of working duration not more than 600h. |
Mileage per year less than 2x 10 ⁴ km and less than 6x 10 ⁴km |
Mileage per year mire than 6x 10 ⁴km |
|
Normal condition |
Bad Condition |
|||
|
A |
B |
C |
D |
E |
|
Good condition and long distance transport, sulfer content of fuel is less than 0.05% |
Short distance transport, engineering truck, bus, etc. |
Off-road, mountain and rugged road |
Hot or cold region ( temperature always |
Sulfer content of fuel more than 0.05% |
|
Service Condition |
WG I |
WGII |
WGIII |
|
First-time Check |
After running 1000~1500km |
After running |
After running |
|
Routine Check（P） |
Every 5000km Every 150h |
Every 1x 10 ⁴km |
Every 1.5x 10 ⁴km |
|
1st-Grade Service |
Every 1x 10 ⁴km Every 300h |
Every 2x 10 ⁴km |
Every 3x 10 ⁴km |
|
2st-Grade Service |
Every 2x 10 ⁴km Every 300h |
Every 4x 10 ⁴km |
Every 6x 10 ⁴km |
|
1st-Grade Service |
Every 4x 10 ⁴km Every 300h |
Every 8x 10 ⁴km |
Every 12x 10 ⁴km |
|
4st-Grade Service |
Every 8x 10 ⁴km Every 300h |
Every 16x 10 ⁴km |
Every 24x 10 ⁴km |
Engine – 380HP, EURO II, with EVB & oil bathing system
Cabin – HW76, with one sleeper, with A/C, airbag driver seat
Cabin – HW76, with one sleeper & A/C
Engine – 420HP, Euro Ⅱ, with oil bathing system
Engine – WD615.69, Euro II emission standard 4 stroke direct injection diesel engine.
Transmission – HW19710,10 forward and 2 reverse
Capacity – 12 cubic meters (10cubic meters, 14cubic meters)
Engine – 380hp
Fuel tank – 400L
Engine – 380HP, EURO II
Lifting capacity – 20 tons, 35 tons
Engine power – 115HP, YUCHAI
© Copyright 2023 SINOTRUK ERATRUCK Ghana Division All Rights Reserved.
Key Word: Dump Truck ,Tractor Truck , Cargo Truck, Tank Truck, Special Truck, Light Truck
Products catalog
Free telephone
Services